|
Building
Wood Stairs By Dave
Markel
Building a set of wood stairs is not nearly
as hard as you may think. With some basic wood tools and a bit of algebra
you can easily build your own. Of course this can get a bit tricky
for stairs with several landings but the method is still the same.
This article will cover the steps for building a straight set of stairs.
Chances are if you are reading this then you are still learning and
won't be taking on a complex stair anyway. Now,
we will assume that it is from a deck to a concrete pad. The deck is
going to be 48" wide and at eye level from the ground.
Tools you will need: Circular saw ;
Framing square; Hand saw; Carpenters pencil; Measuring tape; 4' Level; Masking
tape
You will also need: 3 @ 10' / 2" x
12" boards - Choose the best only, make sure they are straight
with no check (cracks). Very Important!
2 @ 8' / 2" x 4" boards
8 @ 8' / 2" x 6" boards - Once again choose the good ones. These
are going to be the steps so...
1 @ 45" / 2" x 6" boards
1 sheet of plywood @ 1/2" / 8" x 48"
Of course, 3-1/2" framing nails and deck screws or nails for the steps.
Find the overall rise: We want to know the
exact vertical distance from the top of the concrete pad to the top
of the deck. Take one of the 8' 2x4's and rest one end on the deck
and hold the other over the pad, Place the level on the 2x4 and level
the board. Then simply measure from the bottom of the 2x4 to the pad.
Lets say it is 64". This is the overall rise.
Now determine the overall run: Before we can do
this we have to determine how many steps we need.
So first..: Take the overall rise, 64", and
divide it by 7.25", which is the typical height of 1 riser (step).
This gives us 8.83, which rounds up to 9, So we will go with 9 risers.
Important: There is always 1 less tread then risers.
Whether you go up or down the last step is onto the deck or the pad.
So 1 less tread.
Now we take 10.5", the width of a typical
step, and multiply it by 8. This gives us 84". This is the overall
run.
While we are doing the math we need to figure out
the exact rise of each step. We simply take the overall rise of 64" and
divide it by 9 and we get 7.111" or 7-1/8", or close enough
to it. So each riser will be 7-1/8".
Time for some layout: First thing. Grab your framing
square. The long leg is the tread (step) leg and the short leg is the
riser leg. Also, use the numbers on the outside of the square only.
Take some masking tape and wrap a piece around
the framing square to establish you rise and run. Mark 10.5" on
the outside of the long leg and 7-1/8" on the outside of the short
leg.
Layout one of the 2x12's on your saw horses or
work bench. WIth the long leg of your framing square towards the end
of the board start to line up the tape marks to the edge of the board
facing you. Once you have the square in position mark the outside edge
of it with your pencil.
Continue to do this until you have the required
number of steps, 8 in this case. This first riser is always shorter by
the thickness of the steps, for us that is 1.5". This makes the
first riser 5-5/8".
Cut 'em out: Now use you circular saw to cut out
the stringers (technical name for 2x12 with stair marks on it) being
sure to cut on the waste side of the line. When you cut into the corner
with a circular saw the blade misses some of the wood on the bottom side
of the board. This is fine, simply cut up to the line and stop, then
finish the cut with your hand saw.
Now use the first stringer as a template for the
other two. Lay the stringer onto the 2x12's and trace around it. Then
cut out the other stringers the same as the first.
Reinforce the stringers: Align one of the 8' 2x4's
along the bottom edge of the string and mark it to fit the profile of
the ends of the stringers. Cut the 2x4 and secure it to the bottom edge
of the stringer. Repeat this for one other stringer. These help to strengthen
the stringers and reduce "bounce" in the stairs. Use the framing
nails to secure them.
Assemble the stairs: The plywood is used to attach
the stairs to the deck. Secure the sheet of plywood to the top end of
the stringers. The two outside stringers are nailed flush with the edge
of the plywood while the third stringer is centered on the sheet. Simply
nail through the plywood into the face of the stringers using framing
nails. 4 into each stringer will be enough.
Now take the 45" 2x6 and nail it in between
the bottom of the outside stringers. The 2x6 will fit into the notch
cut into the center stringer. This provides the right spacing for the
bottom of the stairs and secures them to the pad.
Attach them to the deck: Move the stairs into their
final position. make sure they are level across the stringers and that
the risers are plumb. When the stairs are positioned correctly nail through
the plywood into the side of the deck. Use some 3" concrete nails
to secure the 2x6 spacer to the concrete pad.
Install the treads: Cut the 8 - 8' 2x6's in half,
be sure to cut them square. Starting at the bottom of the stairs, start
placing the 2x6 stair treads. Simply center them on the stringers and
use some 3"deck nails to attach them. You can also use an exterior
adhesive to assure that they don't move.
Continue to work your way up the stairs until you
reach the top. You are done... well, almost Railings.
You need to install a railing to keep people from falling off.
About The Author: Dave Markel is the author
of "The All Wood Working Journal". He has helped hundreds
of individuals improve their wood working skills. Visit his site at
http://all-wood-working-plans.com.
|